Industry . . . From July, these nine types of VOCs illegal acts, will become the focus of law enforcement everywhere!

the Volatile Organics Non-Tissue Emissions Control Standard (GB37822-2019) will be put into effect on July 1, 2020, which sets out the VOCs material storage non-tissue emission control requirements, VOCs material transfer and transmission of unorganized emissions Control requirements, process VOCs unorganized emission control requirements, equipment and pipeline components VOCs leak control requirements, open liquid surface VOCs unorganized emission control requirements, as well as VOCs unorganized emission collection and treatment system requirements, enterprise plant and surrounding pollution monitoring requirementsExisting enterprises will be executed in accordance with the provisions of the standard, which is enforceable in accordance with the relevant legal provisionsunorganized emissions are relative to organized emissions, which means that atmospheric pollutants do not pass through the exhaust cylinder irregular discharge, the main feature is a wide range of emissions, regulatory difficultiesIn particular, a large number of small and medium-sized enterprises management level is poor, low collection efficiency, the problem of escape is prominentThe research shows that the non-tissue emission of industrial VOCs in China accounts for 60%, that is to say, a considerable part of the VOCs emitted by industrial enterprises are discharged directly into the atmosphere without collection and treatmentTherefore, reducing the unorganized emissions of VOCs is a very important part of air pollution control, especially ozone pollution controlcombined with the current situation analysis, volatile organic matter supervision, will become the second half of this year in the ecological environment departments around the focus of law enforcementThis article lists the nine types of environmental violations that are easy to violate after the implementation of GB 37822, and the relevant enterprises should check themselvesGB 37822 after execution
easy to violate the nine types of environmental violations
, exhaust gas collection system transmission pipe, not using negative pressure state, or positive pressure state when the leak detection value of more than 500 ?mol/molapplicable penalty provisions: Article 108 (1) of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If any of the following acts are violated by this Law, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and shall be fined between 20,000 yuan and 200,000 yuan;2, the exhaust gas using the external exhaust cover (air shield) collection, from the farthest distance from the exhaust cover open surface VOCs tissue emission position, control wind speed did not reach 0.3m/s (industry regulations are specified, according to the relevant provisions)applicable penalty provisions: Article 108 (1) of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If any of the following acts are violated by this Law, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and shall be fined between 20,000 yuan and 200,000 yuan;3For equipment and pipeline components VOCs leakage control, if found in one of the following cases, is illegal, in accordance with the relevant provisions of laws and regulations to deal with:1, the number of enterprise sealing points more than 2000 (inclusive), but did not carry out leak detection and repair work ; Failure to carry out leak detection and repair according to the prescribed frequency and time; 3, on-site random spot checks, in the case of detection of no more than 100 sealing points, found that more than 2 (excluding) not during the repair period of the sealing point visible leakage phenomenon or more than the leakage identified concentration Whether the is carried out in accordance with the prescribed frequency and time to carry out leakage detection and repair work, should be determined according to the account information applicable penalty provisions: Article 108 (1) of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If any of the following acts are violated by this Law, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and shall be fined between 20,000 yuan and 200,000 yuan; , products containing VOCs and organic polymer products are not used in confined equipment or operated in confined spaces during use, or local VOCs collection measures are not taken (except for VOCs products with a quality ratio of less than 10%.) applicable penalty provisions: Article 108 (1) of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If any of the following acts are violated by this Law, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and shall be fined between 20,000 yuan and 200,000 yuan; V Not configured as prescribed VOCs treatment facilities (the initial emission rate of NMHC in the collected exhaust gases shall be configured with the VOC s treatment facility, the treatment efficiency should not be less than 80%; Article 108(1) of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If, in violation of the provisions of this Law, one of the following acts is committed, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and shall be fined between 20,000 yuan and not more than 200,000 yuan; , the height of the exhaust cylinder is less than 15m (except for safety reasons or special process requirements), or the exhaust cylinder is not constructed in accordance with the environmental impact assessment document applicable penalty provisions: Article 100, Item 5 of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If any of the following acts are violated by this Law, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and shall be fined between 20,000 yuan and not more than 200,000 yuan; (5) failing to set up air pollutant discharges in accordance with the provisions 7, VOCs exhaust gas collection and treatment system is not running in sync with the production process equipment (VOCs waste gas collection and treatment system failure or maintenance, the corresponding production process equipment should stop operation, to be completed after the simultaneous use; production process equipment can not stop operation or can stop timely operation, the waste gas emergency treatment facilities or take other alternative measures.) The applicable penalty provisions: Article 108(1) of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: If any of the following acts is violated by this Law, the competent department of ecological environment of the people's government at or above the county level shall order it to be corrected and fined from 20,000 yuan to 200,000 yuan; Or if measures are not taken to reduce emissions, and at the same time, in accordance with Article 63 (3) of the Environmental Protection Law of the People's Republic of China, they shall be transferred to the public security organs for handling: if enterprises and institutions and other production and operation personnel commit one of the following acts and do not constitute a crime, they shall, in addition to punishing them in accordance with the relevant laws and regulations, transfer the case to the public security organ, and the persons in charge and other persons directly responsible for it shall be detained for not more than 15 days; Detained for five days and ten days below: .. (3) Illegally releasing pollutants by means of secret pipes, seepage wells, seepage pits, perfusions or tampering with monitoring data, falsifying monitoring data, or operating normally to prevent and control pollution facilities, etc eight, did not set up a ledger according to regulations, record the main operation and maintenance information of the exhaust gas collection system, VOCs processing facilities, such as running time, exhaust gas treatment volume, operating temperature, stop time, adsorbent regeneration and replacement cycle and replacement amount, catalyst replacement cycle and replacement amount, absorption liquid pH and other key operating parameters The applicable penalty provisions: "Regulations on the Administration of Sewage Permits" (to be issued soon) Article 69 "Violation of the account records (by day penalty)" If any of the following acts are committed, the local ecological environment department at or above the municipal level of the district shall order it to correct it and shall be sentenced to more than one thousand yuan and two per day If the fine is not less than 10,000 yuan; if the administrative organ that refuses to correct it, the administrative organ that makes the decision on punishment according to law may, from the day after the date of ordering the correction, impose continuous punishment on a daily basis in accordance with the original penalty amount: 1 , failing to record the account sewage account sewage regulations; 2, the contents of the account are not true or complete emissions of atmospheric pollutants that exceed the emission standards of atmospheric pollutants In the plant doors and windows or vents, other openings (holes) and other discharges outside 1m, from the ground more than 1.5m position to monitor If the plant is incomplete (if there is no wall), the wind at the operating station 1m, from the ground more than 1.5m position to monitor, in accordance with the monitoring specifications required to measure the monitoring point of any 1 hour average concentration value (6mg/m3) or any one concentration value (20mg/m3) exceeds the limits specified in this standard to determine the excess the applicable penalty provisions: Article 99, item 2, of the Law of the People's Republic of China on the Prevention and Control of Air Pollution: Ordering correction, restricting production, stopping production and rectification, and imposing a fine of 100,000 yuan to less than 1 million yuan; ..... (2) Emissions of atmospheric pollutants that exceed the emission standards of atmospheric pollutants or exceed the total emission control targets of key atmospheric pollutants